3,200sq. Ft. Warehouse/help With Setup

Lyfespan · May 18, 2015

What's the ceiling height in those walkin coolers? Is there enough room for lights?

CannabisJohn · May 18, 2015

Lyfespan said:
What's the ceiling height in those walkin coolers? Is there enough room for lights?

The inside is a metal finish. You can get them in any height that u want. They go up fast. The draw back is that is usually takes 3-4 weeks to get them after u order. Also they maybe more expensive than regular construction depending on your area of the world or country.

Lyfespan · May 18, 2015

I have put up the smaller side by side units for Subways, but those are the 6-8' tall units.

There a breeze to put up, even for one man ops. These units are a hell of a lot better use of cooling equipment, only worry is keeping some humidity in there.

I went to the site, a 12' unit would perfect, and you can always start out small and add to it like Legos, just think, you could even have a pressure locked clean system, with a scrub room, have it all sterile

CannabisJohn said:
The inside is a metal finish. You can get them in any height that u want. They go up fast. The draw back is that is usually takes 3-4 weeks to get them after u order. Also they maybe more expensive than regular construction depending on your area of the world or country.

Spectre · May 19, 2015

Rooms 1 & 2 are framed and covered. I went with the suggested 2" R-Max for the main wall and dividing wall. I taped all the seams inside the rooms with foil tape, then spray foam from behind to really seal everything up.

blazedahaze · May 19, 2015

Looking good @Spectre I would have used treated lumber for the bottom plate. Or did you just use a piece of plastic as a barrier between the bottom plate and the concrete? Only reason I say this is because at my last spot I didn't use treated lumber for my plates and when I tore down, there was mold everywhere. The untreated lumber will literally suck up all the moisture it can from the floor leading to moisture issues inside the walls.

Spectre · May 19, 2015

blazedahaze said:
Looking good @Spectre I would have used treated lumber for the bottom plate. Or did you just use a piece of plastic as a barrier between the bottom plate and the concrete? Only reason I say this is because at my last spot I didn't use treated lumber for my plates and when I tore down, there was mold everywhere. The untreated lumber will literally suck up all the moisture it can from the floor leading to moisture issues inside the walls.

There is a layer of visqueen under the plate. The walls are all screwed together so I can easily dismantle once I can get a steel stud frame in there.

Herb Forester · May 19, 2015

What kind of caulk did you use for the r-max?

Smokey503ski · May 19, 2015

This is going to be awesome!

Spectre · May 19, 2015

Herb Forester said:
What kind of caulk did you use for the r-max?

It's expanding foam sealant.

http://www.homedepot.com/p/GREAT-STUFF-16-oz-Pestb-Insulating-Foam-Sealant-11034540/203282346

Texas Kid · May 20, 2015

Damn, I love new build outs!! good on ya my brutha, keep on doing it up.

Passion Baby!!!

Billyboat · May 20, 2015

Looking sharp!

DirtySanchez · May 20, 2015

woop woop!!!! Went with the Rmax & great stuff. We've done this for YEARS and it works like a charm!.. Might want to throw a layer of pink panther if you're in a climate with wild temp swings.

Super pumped, love to see the new build going along well!

I have a lot of experience building these types of grows. @texaskid would be the one to talk to if you're trying to pass an inspection. If you're trying to build something that goes up and down quickly I'm always here to help!

Got a feeling this one is gonna be awesome!

pharmafarmer · May 30, 2015

Bad ass! Loving following your build

Spectre · Jun 2, 2015

Thanks for all the positive support everyone!

Electrical is finally finished.. It's already set up for future expansion.

Getting everything hooked up and tested. Luckily haven't had any equipment problems thus far!

stonedcold · Jun 6, 2015

Killer build mang.... ? For u does that rmax help in sound deadening? ?? Im building a few walls using that to n am unsure if i should worry about noise...maybe some ppink stuffing to?? Did u insulate with the pink stuff oand the sheath it or is the rmax take care of it all????
Also just wanna say what up tex... still got some of u n lonestars trc gear will be in my room for life

Spectre · Jun 6, 2015

stonedcold said:
Killer build mang.... ? For u does that rmax help in sound deadening? ?? Im building a few walls using that to n am unsure if i should worry about noise...maybe some ppink stuffing to?? Did u insulate with the pink stuff oand the sheath it or is the rmax take care of it all????
Also just wanna say what up tex... still got some of u n lonestars trc gear will be in my room for life

I don't think it does much for sound. I don't have everything up and running so I'm not sure yet.

I didn't put any insulation yet but I definitely will in the future. The 2" R-MAX is rated the same as the 2" pink insulation (r-13) but doubling up never hurts, especially if you're running a sealed room.

what crosses do you have from trc? feel free to show..

DirtySanchez · Jun 6, 2015

The rmax definitely does muffle the sound... Is it going to completely cover the sound of 20 can fans buzzing?.. Probably not.

We've used those egg crate sound barrier things they use in music studios back in the good old days when we had to be completely stealth in close quarters. Stuff them between the wall and the rmax.

stonedcold · Jun 8, 2015

Thanks guys ya def gonna still insulate n sheat rock plywood left over the other invisible side of the 2 walls... i picked 25 sheets today shit this stuff is lightweight gonna be a breeze hanging it.. finding this thread was awesome first time i checked the farm in a long time on my way out the door to buy sheetrock now probably never gonna use sheet rock again...
Ya them egg cartons are the shit dead silence. .. used them all the time back home NYC. But here its not necessary. .. pink stuff will do... you guys are awesome cant wait to see this room rockin.... What strains u running? ??? My phone is acting up cant post pics till i get to my tab... both trc cuts have womens names... peace

DirtySanchez · Jun 8, 2015

Spec what nutes u runnin?

Updates please!!! U got us all waiting

DirtySanchez · Jun 8, 2015

Spec what nutes u runnin?

Updates please!!! U got us all waiting

3,200sq. Ft. Warehouse/help With Setup

3,200sq. Ft. Warehouse/help With Setup

Lyfespan

CannabisJohn

Lyfespan

Spectre

blazedahaze

Spectre

Herb Forester

Smokey503ski

Spectre

Texas Kid

Some guy with a light

Billyboat

Moderator

DirtySanchez

pharmafarmer

Spectre

stonedcold

Spectre

DirtySanchez

stonedcold

DirtySanchez

DirtySanchez

3,200sq. Ft. Warehouse/help With Setup

3,200sq. Ft. Warehouse/help With Setup

Lyfespan

CannabisJohn

Lyfespan

Spectre

blazedahaze

Spectre

Herb Forester

Smokey503ski

Spectre

Texas Kid

Some guy with a light

Billyboat

Moderator

DirtySanchez

pharmafarmer

Spectre

stonedcold

Spectre

DirtySanchez

stonedcold

DirtySanchez

DirtySanchez

Privacy & Transparency

Privacy & Transparency